對于混凝土攪拌車的干燥罐，竟然有用戶不是很在意，那這個是錯誤的想法，干燥罐對于設備的使用還是有很大的作用的，那么混凝土攪拌車的干燥罐什么時候更換呢？下面我們就來聊聊問題相關內容吧。

　　For the drying tank of the concrete mixer, there are users who do not care about it very much. That is a wrong idea. The drying tank still plays a great role in the use of equipment. Let's talk about the problem.

　　混凝土攪拌車的干燥罐用于過濾氣路系統中壓縮空氣中的水蒸氣，防止儲氣筒和各種泵閥被腐蝕。因此，混凝土攪拌車的干燥罐能否正常工作，將直接影響制動器的性能。然而在現實中，多卡的朋友們往往因為對干燥罐的不完全了解而忽略了它的存在。

　　The drying tank of the concrete mixer is used to filter the water vapor in the compressed air of the air passage system and prevent the air storage cylinder and various pump valves from being corroded. Therefore, whether the drying tank of concrete mixer can work normally will directly affect the performance of brake. In reality, however, Dorka's friends tend to ignore dry POTS because they don't fully understand them.

　　更換干燥罐的操作并不復雜，用儲氣罐底部的放氣閥檢查儲氣罐底部是否潮濕或有水。如果干燥罐出現故障，打開閥門后會有水流出，應立即更換新的干燥罐。

　　The operation of replacing the dry tank of the cement mixer is not complicated. Check whether the bottom of the tank is wet or water with the vent valve at the bottom of the tank. If the drying tank fails, water will flow out after opening the valve, and a new drying tank should be replaced immediately.

　　那么混凝土攪拌車的干燥罐什么時候更換？很多人可能不會每隔幾年換一次，只要沒問題。而且不同品牌的干燥罐使用壽命不同，車輛的氣候環境也不同，更換周期難以統一。

　　So when will the drying tank of the concrete mixer be replaced? A lot of people probably don't switch every few years, as long as it's okay. Moreover, the service life of drying tanks of different brands is different, the climatic environment of vehicles is also different, and the replacement cycle is difficult to be unified.

　　如果混凝土攪拌車司機實在不知道什么時候更換，可以通過檢查儲氣罐是否有水來判斷。不過也想提醒各位司機朋友，由于混凝土攪拌車的干燥罐與氣路相連，罐內與外界存在一定的壓差。壓縮空氣未排空時，貿然拆卸，瞬間釋放壓縮空氣，使用方便。

　　If the concrete mixer driver really doesn't know when to replace it, he can tell by checking the gas tank for water. However, I also want to remind you that because the drying tank of the concrete mixer is connected with the gas road, there is a certain pressure difference between the tank and the outside world. When the compressed air is not empty, it can be hastily disassembled to release the compressed air instantly, which is convenient to use.

　　因此，在拆卸干燥罐之前，一定要排空儲氣罐中的空氣（反復踩剎車直到氣壓表讀數歸零）。用專用扳手取下干燥罐后，可以看到底座上有水滴，說明壓縮空氣的濕度還是很高的。

　　Therefore, before removing the drying tank, be sure to empty the air in the tank (repeatedly apply the brake until the barometer reads zero). After removing the drying tank with a special wrench, you can see water droplets on the base, indicating that the humidity of compressed air is still very high.

　　如果干燥罐的過濾效果不好，液態水會通過氣路進入制動器的各個泵閥。安裝新的干燥罐前，先清潔底座頂部，防止油漬進入新罐內部，影響除濕性能。然后在新干燥罐下方的橡膠墊片上涂一層油，起到潤滑作用，防止安裝時損壞橡膠墊片。

　　If the filtration of the drying tank is not good, liquid water will enter the pump valves of the brake through the air path. Before installing a new drying tank, clean the top of the base to prevent oil stains from entering the new tank and affecting the dehumidification performance. Then apply a layer of oil to the rubber gasket under the new drying tank to lubricate it and prevent damage to the rubber gasket during installation.

　　混凝土攪拌車的干燥罐是不可忽視的重要因素，如果使用劣質產品，或者長時間不更換除濕性能下降，都會嚴重影響整車性能制動。所以需要定期對混凝土攪拌車的干燥罐進行更換，還有不懂得問題可以隨時來咨詢我們www.zkzdsljbc.com！

　　The drying tank of concrete mixer truck is an important factor that can not be ignored. If inferior products are used, or dehumidification performance decreases without replacement for a long time, performance braking of the whole vehicle will be seriously affected. Therefore, it is necessary to replace the drying tank of the concrete mixer truck on a regular basis, and you can always consult us at www.zkzdsljbc.com!